MATERIAL SAFETY DATA SHEET

SECTION I - Identity – AQUA-5 EPOXY CONCRETE PATCH (MIX A)

ES INDUSTRIAL CORP.  P.O. BOX 843 RED BANK, NJ 07701

Date Prepared  05-11-2000   For Emergency   800-877-2436   For Information  800-877-2436

SECTION II – HAZARDOUS INGREDIENTS/IDENTITY INFORMATION

Hazardous Component(s)              CAS #                      OSHA  PEL             ACGIH  TLV                  Other Limits              %(opt)  

EPOXY RESIN                                25068-36-6                UNKNOWN             UNKNOWN                                                       100

SECTION III – PHYSICAL & CHEMICAL CHARACTERISTICS

Boiling Point:   N/A             Specific Gravity (H2O = 1): N/A    Vapor Pressure (mm Hg):  N/A

Melting Point: N/A                Vapor Density (Air =1): HEAVIER THAN AIR           Evaporation Rate(Water = 1):SLOWER THAN ETHER

Solubility % Water:  N/A       Appearance & Odor: 

SECTION IV – FIRE AND EXPLOSION HAZARD DATA

Flash Point (Method Used): NONE    Flammable Limits in Air/Volume: Lower : NONE    Upper:NONE

Extinguisher Media: REGULAR FOAM, CARBON DIOXIDE  OR DRY CHEMICAL    Special Fire Fighting Procedures:  SELF-CONTAINED BREATHING APPARATUS WITH A FULL FACE PIECE OPERATED IN POSITIVE PRESSURE MODE  

Unusual Fire/Explosion Hazards: NONE

SECTION V – REACTIVITY DATA

Stability-Cond to Avoid: STABLE     Hazardous Polymerization-Cond. To Avoid: CANNOT OCCUR

Hazardous Decomposition Products: MAY FORM TOXIC MATERIALS- CARBON DIOXIDE AND CARBON MONOXIDE, VARIOUS HYDROCARBONS

Incompatibility (Materials to Avoid): AVOID CONTACT WITH STRONG OXIDIZING AGENTS (E.G. NITRIC ACID, PERMANGANATES, ETC.)

SECTION VI – HEALTH HAZARDS DATA

Routes of Entry: Inhalation :  X  Skin:  X   Ingestion:  X    Health Hazards(Acute & Chronic) NONE KNOWN

Signs & Symptoms of Overexposure:  EYES:  CAN CAUSE SEVERE IRRITATION, REDNESS, TEARING, BLURRED VISION   SKIN:  CAN CAUSE MODERATE IRRITATION, DEFATTING, DERMATITIS   INHALATION:  CAN CAUSE NAUSEA AND HEADACHE, POSSIBLE UNCONSCIOUSNESS, AND EVEN ASPHYXIATION   INGESTION:  CAN CAUSE GASTROINTESTINAL IRRITATION, NAUSEA, VOMITTING, AND DIARRHEA.  ASPIRATION OF MATERIAL INTO THE LUNGS CAN CAUSE CHEMICAL PNEUMOCONIOSIS WHICH CAN BE FATAL

Chemical Listed as Carcinogen: NONE     NTP: NO     IARC Monographs: NO

Condition Generally Aggravated by Exposure: NONE KNOWN

Emergency and First Aid Procedures

Inhalation    REMOVE INDIVIDUAL TO FRESH AIR.  IF BREATHING HAS STOPPED, GIVE ARTIFICIAL RESPIRATION.  KEEP PERSON WARM, QUIET, AND CONSULT A PHYSICIAN

Eyes        FLUSH WITH LARGE AMOUNTS OF WATER, LIFTING UPPER AND LOWER LIDS OCCASIONALLY.  CONSULT A PHYSICIAN. 

Skin            THOROUGHLY WASH EXPOSED AREA WITH SOAP AND WATER.  REMOVE CONTAMINATED CLOTHING.  LAUNDER CONTAMINATED CLOTHING BEFORE RE-USE.

Ingestion    DO NOT INDUCE VOMITTING, KEEP PERSON WARM, QUIET, AND CONSULT A PHYSICIAN.

SECTION VII – PRECAUTIONS FOR SAFE HANDLING AND USE

Handling & Storage Precautions:  N/A

Other Precautions:  CONTAINERS OF THIS MATERIAL MAY BE HAZARDOUS WHEN EMPTIED.  SINCE EMPTIED CONTAINERS RETAIN PRODUCT RESIDUES (VAPOR, LIQUID, AND/OR SOLID), ALL HAZARD PRECAUTIONS GIVEN IN THIS DATA SHEET MUST BE OBSERVED.  KEEP OUT OF REACH OF CHILDREN.

If Material is Released/Spilled:  SMALL SPILL:  ABSORB LIQUID ON PAPER, VERMICULITE, FLOOR ABSORBENT, OR OTHER ABSORBENT MATERIAL AND TRANSFER TO VENTILATED CLOSURE.   LARGE SPILL:  ELIMINATE ALL IGNITION SOURCES (FLARES, FLAMES INCLUDING PILOT LIGHTS, ELECTRICAL SPARKS, ETC.).  PERSONS NOT WEARING PROTECTIVE EQUIPMENT SHOULD BE EXCLUDED FROM AREA OF SPILL.  STOP SPILL AT SOURCE, DIKE AREA OF SPILL TO PREVENT SPREADING, PUMP LIQUID TO SALVAGE TANK.  REMAINING LIQUID MAY BE TAKEN UP ON SAND, CLAY, EARTH, FLOOR ABSORBENT, OR OTHER ABSORBENT MATERIAL AND SHOVELED INTO CONTAINERS.

Waste Disposal:  DISPOSE OF IN ACCORDANCE WITH LOCAL, STATE, AND FEDERAL REG.  

SECTION VIII– CONTROL MEASURES

Respiratory Protection:  IF TLV OF THE PRODUCT IS EXCEEDED, A NIOSH/MESA JOINTLY APPROVED SELF-CONTAINED BREATHING APPARATUS WITH A FULL FACE PIECE OPERATED IN POSITIVE PRESSURE MODE OR OTHER NIOSH/MESA RESPIRATORS UNDER SPECIFIED CONDITIONS,    Ventilation Local/Mechanical:  PROVIDE SUFFICIENT MECHANICAL (GENERAL) AND.OR LOCAL EXHAUST VENTILATION TO MAINTAIN EXPOSURE BELOW TLV’S

Special: NONE     Other:         Protective Gloves:  WEAR RESISTANT GLOVES LIKE BUNA-N    Eye Protection:  CHEMICAL SPLASH GOGGLES IN COMPLIANCE WITH OSHA REGULATIONS ARE ADVISED, HOWEVER, OSHA REGULATIONS ALSO PERMIT OTHER TYPE SAFETY GLASSES

Protective Clothing Equipment:  TO PREVENT REPEATED OR PROLONGED SKIN CONTACT WEAR IMPERVIOUS CLOTHING AND BOOTS        Work/Hygienic Practices:  WASH HANDS AFTER USING